2004 Mercury Monterey

News - Crash Test Results:

---

Frontal Driver: * * * * *

Frontal Passenger: * * * * *

Side Driver: * * * *

Side Rear Passenger: * * * * *

Crash Test Note: Results based on a 35 MPH frontal crash and 38.5 MPH side crash. Results are reported in a range of one to five stars, with five stars indicating the best crash protection for vehicles within the same weight class. This test used driver and passenger belts and airbags.

NHTSA Rollover Rating: * * * *

Rollover Note: The Rollover Resistance Rating is an estimate of your risk of rolling over if you have a single vehicle crash. It does not predict the likelihood of that crash. The Rollover Resistance Rating utilizes a "fishhook" maneuver which is a series of abrupt turns at varying speeds to see how "top-heavy" a vehicle is. The more "top-heavy" the vehicle, the more likely it is to roll over. The lowest rated vehicles (1-star) are at least four times more likely to roll over than the highest rated vehicles (5-stars).


Recall:

---

NHTSA CAMPAIGN ID: 03V457000

NHTSA CAMPAIGN ID: 04V446000

Mfg's Report Date: 11/05/2003

Mfg's Report Date: 09/09/2004

Component: STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS

Component: WHEELS:CAP/COVER/HUB

Potential Number of Units Affected: 23996

Potential Number of Units Affected: 34013

Summary: ON CERTAIN MINIVANS, THE POWER STEERING LOW-PRESSURE LINE MAY NOT BE FULLY SEATED AT THE RACK AND PINION STEERING GEAR.

Summary: CERTAIN MINIVANS MAY HAVE BEEN PRODUCED WITH FRONT WHEEL HUB ASSEMBLIES THAT WERE NOT HEAT TREATED CORRECTLY. THIS CONDITION MAY LEAD TO THE DEVELOPMENT OF SMALL CRACKS IN THE HUB.

Consequence: IF THIS LINE BECOMES DISCONNECTED, IT MAY CREATE THE POTENTIAL FOR FLUID TO COME INTO CONTACT WITH THE EXHAUST SYSTEM, WHICH COULD RESULT IN SMOKE OR FIRE.

Consequence: IF THE CRACKS WERE TO PROGRESS, THIS COULD EVENTUALLY RESULT IN WHEEL SEPARATION. WHEEL SEPARATION MAY LEAD TO LOSS OF VEHICLE CONTROL, AND POTENTIALLY RESULT IN A VEHICLE CRASH.

Remedy: DEALERS WILL INSPECT THE POWER STEERING LOW-PRESSURE LINE TO ENSURE THAT IT IS SEATED PROPERLY AT THE RACK AND PINION STEERING GEAR. OWNER NOTIFICATION BEGAN NOVEMBER 10, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

Remedy: DEALERS WILL REPLACE THE FRONT HUB, ROTORS, AND WHEEL BEARINGS. THE RECALL BEGAN SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

Notes: FORD RECALL NO. 03S09. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Notes: FORD RECALL NO. 04S24. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

- NONE -