2004 Honda Accord Sdn

Recall:

---

NHTSA CAMPAIGN ID: 04V551000

NHTSA CAMPAIGN ID: 04V176000

NHTSA CAMPAIGN ID: 07V001000

Mfg's Report Date: 11/17/2004

Mfg's Report Date: 04/13/2004

Mfg's Report Date: 01/02/2007

Component: AIR BAGS:FRONTAL

Component: POWER TRAIN:AUTOMATIC TRANSMISSION

Component: AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE

Potential Number of Units Affected: 257616

Potential Number of Units Affected: 1099796

Potential Number of Units Affected: 81000

Summary: ON CERTAIN SEDANS, A TEAR IN THE FABRIC OF THE DRIVER'S FRONT AIR BAG OCCURRED AFTER APPARENT CONTACT WITH THE INSIDE SURFACE OF THE AIR BAG COVER DURING DEPLOYMENT.

Summary: ON CERTAIN VEHICLES, THE SEAT POSITION SENSOR (SPS) DETECTS THE DRIVER'S SEATING POSITION AND ADJUSTS THE AIR BAG INFLATION PRESSURE ACCORDINGLY. THE WIRING HARNESS FOR THE SPS WAS ATTACHED TO THE SEAT FRAME IN THE WRONG LOCATION AND MAY HAVE BEEN OVER TIGHTENED. THE SENSOR WIRE MAY BREAK AND CAUSE THE AIR BAG WARNING LIGHT TO BE ILLUMINATED, AND THE SPS TO FAIL.

Summary: ON SOME MINI VANS, SPORT UTILITY AND PASSENGER VEHICLES, CERTAIN OPERATING CONDITIONS CAN RESULT IN HEAT BUILD-UP BETWEEN THE COUNTERSHAFT AND SECONDARY SHAFT SECOND GEARS IN THE AUTOMATIC TRANSMISSION, EVENTUALLY LEADING TO GEAR TOOTH CHIPPING OR GEAR BREAKAGE.

Consequence: A TORN AIR BAG MAY NOT OFFER THE SAME LEVEL OF PROTECTION, IN THE EVENT OF A CRASH, THEREBY INCREASING THE RISK OF INJURY TO THE DRIVER.

Consequence: A FAILURE OF THE SPS CAUSES THE AIR BAG SYSTEM TO DEFAULT TO FULL INFLATION PRESSURE, REGARDLESS OF THE SEAT POSITION. FULL DEPLOYMENT OF THE DRIVER'S AIR BAG CAN INCREASE THE RISK OF INJURY FOR SMALLER DRIVERS IN A FRONTAL CRASH.

Consequence: GEAR FAILURE COULD RESULT IN TRANSMISSION LOCKUP, WHICH COULD RESULT IN A CRASH.

Remedy: DEALERS WILL INSTALL A PROTECTIVE FABRIC FLAP BETWEEN THE AIR BAG MODULE COVER AND THE INNER MODULE. THE RECALL BEGAN ON NOVEMBER 30, 2004. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009.

Remedy: ON VEHICLES WITH 15,000 MILES OR LESS, THE DEALER WILL UPDATE THE TRANSMISSION WITH A SIMPLE REVISION TO THE OIL COOLER RETURN LINE TO INCREASE LUBRICATION TO THE SECOND GEAR. ON VEHICLES WITH MORE THAN 15,000 MILES, THE DEALER WILL INSPECT THE TRANSMISSION TO IDENTIFY GEARS THAT HAVE ALREADY EXPERIENCED DISCOLORATION DUE TO OVERHEATING. IF DISCOLORATION EXISTS, THE TRANSMISSION WILL BE REPLACED IF DISCOLORATION IS NOT PRESENT, THE DEALER WILL PERFORM THE REVISION TO THE OIL COOLER RETURN LINE. THE RECALL BEGAN ON APRIL 21, 2004, FOR PILOT, ODYSSEY, AND MDX OWNERS. OWNERS OF THE ACCORD VEHICLES WILL START RECEIVING LETTERS ON JUNE 28, 2004, AND ON JUNE 29, 2004, FOR OWNERS OF THE TL AND CL VEHICLES. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.

Remedy: DEALERS WILL REPLACE THE SEAT POSITION SENSOR WIRING SUBHARNESS. THE RECALL IS EXPECTED TO BEGIN DURING EARLY FEBRUARY 2007. OWNERS MAY CONTACT HONDA AT 1-800-999-1009.

Notes: HONDA RECALL NO. P54. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Notes: HONDA RECALL NOS. P30 (ODYSSEY AND PILOT), P31 (MDX), P38 (ACCORD) AND P39 (ACURA). CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Notes: CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

- NONE -